[Federal Register: March 19, 1998 (Volume 63, Number 53)]
[Proposed Rules]               
[Page 13381-13383]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr19mr98-20]

-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 98-CE-11-AD]
RIN 2120-AA64

 
Airworthiness Directives; Glaser-Dirks Flugzeugbau GmbH Model DG-
400 Gliders

AGENCY: Federal Aviation Administration, DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: This document proposes to adopt a new airworthiness directive 
(AD) that would apply to Glaser-Dirks Flugzeugbau GmbH (Glaser-Dirks) 
Model DG-400 gliders. The proposed AD would require replacing the Bosch 
electrical system regulator, part number (P/N) 0212920001, with a type 
4 E 26 regulator. The proposed AD is the result of mandatory continuing 
airworthiness information (MCAI) issued by the airworthiness authority 
for Germany. The actions specified by the proposed AD are intended to 
prevent failure of the electrical system regulator, which could result 
in smoke entering the cockpit with consequent passenger injury.

DATES: Comments must be received on or before April 17, 1998.

ADDRESSES: Submit comments in triplicate to the Federal Aviation 
Administration (FAA), Central Region, Office of the Regional Counsel, 
Attention: Rules Docket No. 98-CE-11-AD, Room 1558, 601 E. 12th Street, 
Kansas City, Missouri 64106. Comments may be inspected at this location 
between 8 a.m. and 4 p.m., Monday through Friday, holidays excepted.
    Service information that applies to the proposed AD may be obtained 
from DG Flugzeugbau GmbH, Postfach 4120, D-76625 Bruchsal 4, Germany; 
telephone: +49 7257-89-0; facsimile: +49 7257-8922. This information 
also may be examined at the Rules Docket at the address above.

FOR FURTHER INFORMATION CONTACT: Mr. Mike Kiesov, Aerospace Engineer, 
Small Airplane Directorate, Aircraft Certification Service, FAA, 1201 
Walnut, suite 900, Kansas City, Missouri 64106; telephone: (816) 426-
6934; facsimile: (816) 426-2169.

SUPPLEMENTARY INFORMATION:

Comments Invited

    Interested persons are invited to participate in the making of the 
proposed rule by submitting such written data, views, or arguments as 
they may desire. Communications should identify the Rules Docket number 
and be submitted in triplicate to the address specified above. All 
communications received on or before the closing date for comments, 
specified above, will be considered before taking action on the 
proposed rule. The proposals contained in this notice may be changed in 
light of the comments received.
    Comments are specifically invited on the overall regulatory, 
economic, environmental, and energy aspects of the proposed rule. All 
comments submitted will be available, both before and after the closing 
date for comments, in the Rules Docket for examination by interested 
persons. A report that summarizes each FAA-public contact concerned 
with the substance of this proposal will be filed in the Rules Docket.
    Commenters wishing the FAA to acknowledge receipt of their comments 
submitted in response to this notice must submit a self-addressed, 
stamped postcard on which the following statement is made: ``Comments 
to Docket No. 98-CE-11-AD.'' The postcard will be date stamped and 
returned to the commenter.

Availability of NPRMs

    Any person may obtain a copy of this NPRM by submitting a request 
to the FAA, Central Region, Office of the Regional Counsel, Attention: 
Rules Docket No. 98-CE-11-AD, Room 1558, 601 E. 12th Street, Kansas 
City, Missouri 64106.

Discussion

    The Luftfahrt-Bundesamt (LBA), which is the airworthiness authority 
for Germany, notified the FAA that an unsafe condition may exist on all 
Glaser-Dirks Model DG-400 gliders. The LBA reports several incidents of 
defective Bosch electrical system regulators, part number (P/N) 
0212920001.
    This condition, if not corrected in a timely manner, could result 
in failure of the electrical system regulator and

[[Page 13382]]

smoke entering the cockpit with consequent passenger injury.

Relevant Service Information

    Glaser-Dirks has issued DG Flugzeubau GmbH Technical Note No. 826/
33, dated July 19, 1996, which specifies replacing the Bosch electrical 
system regulator, part number (P/N) 0212920001, with a type 4 E 26 
regulator. The procedures for accomplishing this replacement are 
included in DG Flugzeugbau GmbH Z 33 Conversion Kit Saprisa regulator 
Installation Instructions, dated July 4, 1996, and Glaser-Dirks Drawing 
4 E 26.
    The LBA classified this service information as mandatory and issued 
German AD 96-242, dated August 29, 1996, in order to assure the 
continued airworthiness of these gliders in Germany.

The FAA's Determination

    This glider model is manufactured in Germany and is type 
certificated for operation in the United States under the provisions of 
section 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and 
the applicable bilateral airworthiness agreement. Pursuant to this 
bilateral airworthiness agreement, the LBA has kept the FAA informed of 
the situation described above.
    The FAA has examined the findings of the LBA; reviewed all 
available information, including the service information referenced 
above; and determined that AD action is necessary for products of this 
type design that are certificated for operation in the United States.

Explanation of the Provisions of the Proposed AD

    Since an unsafe condition has been identified that is likely to 
exist or develop in other Glaser-Dirks Model DG-400 gliders of the same 
type design registered in the United States, the FAA is proposing AD 
action. The proposed AD would require replacing the Bosch electrical 
system regulator, part number (P/N) 0212920001, with a type 4 E 26 
regulator. Accomplishment of the proposed installation would be in 
accordance with the service information previously referenced.

Compliance Time of the Proposed AD

    Although failure of the electrical system regulator will only be 
unsafe while the glider is in flight, this unsafe condition is not a 
result of the number of times the glider is operated. The chance of 
this situation occurring is the same for a glider with 10 hours time-
in-service (TIS) as it is for a glider with 500 hours TIS. For this 
reason, the FAA has determined that a compliance based on calendar time 
should be utilized in the proposed AD in order to assure that the 
unsafe condition is addressed on all gliders in a reasonable time 
period.

Cost Impact

    The FAA estimates that 35 gliders in the U.S. registry would be 
affected by the proposed AD, that it would take approximately 2 
workhours per glider to accomplish the proposed action, and that the 
average labor rate is approximately $60 an hour. Parts cost 
approximately $200 per glider. Based on these figures, the total cost 
impact of the proposed AD on U.S. operators is estimated to be $11,200, 
or $320 per glider.

Regulatory Impact

    The regulations proposed herein would not have substantial direct 
effects on the States, on the relationship between the national 
government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, in 
accordance with Executive Order 12612, it is determined that this 
proposal would not have sufficient federalism implications to warrant 
the preparation of a Federalism Assessment.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) if promulgated, 
will not have a significant economic impact, positive or negative, on a 
substantial number of small entities under the criteria of the 
Regulatory Flexibility Act. A copy of the draft regulatory evaluation 
prepared for this action has been placed in the Rules Docket. A copy of 
it may be obtained by contacting the Rules Docket at the location 
provided under the caption ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Safety.

The Proposed Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration proposes to amend 
part 39 of the Federal Aviation Regulations (14 CFR part 39) as 
follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding a new airworthiness directive 
(AD) to read as follows:

Glaser-Dirks Flugzeugbau GMBH: Docket No. 98-CE-11-AD.

    Applicability: Model DG-400 gliders, all serial numbers, 
certificated in any category.

    Note 1: This AD applies to each glider identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For gliders that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (c) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required within the next 4 calendar months after the 
effective date of this AD, unless already accomplished.
    To prevent failure of the electrical system regulator, which 
could result in smoke entering the cockpit with consequent passenger 
injury, accomplish the following:
    (a) Replace the Bosch electrical system regulator, part number 
(P/N) 0212920001, with a type 4 E 26 regulator in accordance with DG 
Flugzeugbau GmbH Z 33 Conversion Kit Saprisa regulator Installation 
Instructions, dated July 4, 1996, and Glaser-Dirks Drawing 4 E 26. 
These documents are referenced in DG Flugzeubau GmbH Technical Note 
No. 826/33, dated July 19, 1996.
    (b) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the glider to a location where the 
requirements of this AD can be accomplished.
    (c) An alternative method of compliance or adjustment of the 
compliance time that provides an equivalent level of safety may be 
approved by the Manager, Small Airplane Directorate, FAA, 1201 
Walnut, suite 900, Kansas City, Missouri 64106. The request shall be 
forwarded through an appropriate FAA Maintenance Inspector, who may 
add comments and then send it to the Manager, Small Airplane 
Directorate.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Small Airplane Directorate.

    (d) Questions or technical information related to the service 
information referenced in this AD should be directed to DG 
Flugzeugbau GmbH, Postfach 4120, D-76625 Bruchsal 4, Germany; 
telephone: +49 7257-89-0; facsimile: +49 7257-8922. This service 
information may be examined at the FAA, Central Region, Office of 
the Regional Counsel, Room 1558, 601 E. 12th Street, Kansas City, 
Missouri 64106.

    Note 3: The subject of this AD is addressed in German AD 96-242, 
dated August 29, 1996.


[[Page 13383]]


    Issued in Kansas City, Missouri, on March 11, 1998.
Michael Gallagher,
Manager, Small Airplane Directorate, Aircraft Certification Service.
[FR Doc. 98-7090 Filed 3-18-98; 8:45 am]
BILLING CODE 4910-13-U